Position：Home >> Abstract

Study on the application of active cross-flow membrane equipment in the MBR process of sewage treatment
Authors： LIU Haoliang,GENG Anchao
Units： College of Ocean Environment and Engineering, Shanghai Maritime University, Shanghai 201306, China
KeyWords： membrane separation equipment; cross-flow operation; MBR process; domestic sewage; advanced treatment
ClassificationCode：TQ051.8+93
year,volume(issue):pagination： 2013, 33(6):97-101

Abstract：

An independent research on active cross-flow membrane separation equipment was used in anaerobic/anoxic/oxic process (A/A/O) to treat urban sewage. The membrane device was directly installed in the aeration tank, and it implemented active cross-flow filtration by programmed rotation operation. The experimental results demonstrated that the effluent COD and NH4+- N were below 40 mg/L and 1 mg/L. The removal rate of COD and NH4+- N were 91.3% and 98%, respectively. Cake layer could be prevented effectively because of fluid shear force on the membrane surface and powerful turbulence generated in the device rotation in the case of sludge concentration up to 16000 mg/L. The speed of membrane fouling was significantly slowed down, and membrane equipment showed excellent anti-blocking and anti-pollution ability. During the experiment, the membrane flux remained stable and the operating pressure of the membrane increased slowly. The chemical cleaning cycle was selected for 80 days without any maintenance cleaning. The operation energy consumption of the membrane equipment could reduce 60% than traditional aeration operation. 

Funds：

AuthorIntro：
刘浩亮（1989- ），男，湖北人，硕士，从事膜设备处理生活污水研究. 联系方式：jacklhlchina@163.com.通讯作者：耿安朝（1962- ），男，教授，主要从事水处理与膜分离技术研究. 电子邮箱：genganchao@163.com

Reference：

[1] 郑宏林，俞三传，周勇，等. 中空纤维帘式与平板式膜组件在浸没式MBR中的对比试
用研究[J]. 水处理技术，2009，35（3）：73~77.
[2] Hai F I，Yamamoto K，Fukushi K．Different fouling modes of submerged hollow-fiber and flat-sheet membranes induced by high strength wastewater with concurrent biofouling[J]. Desalination，2005，180(1/2/3)：83~97．
[3] Trussell R S，Merlo R P，Hermanowicz S W，et a1．Influence of mixed liquor properties and
aeration intensity on membrane fouling in a submerged membrane bioreactor at high mixed liquor
suspended solids concentrations[J]．Water Research，2007，41(5)：947~958．
[4] 刘建超，张永刚.浸没式中空纤维膜生物反应器的膜污染及防治对策[J]. 膜科学与技
术，2010，30（4）：84~88.
[5] 黄霞，左名景，薛涛，等. 膜生物反应器脱氮除磷工艺处理城市污水的工程应用[J]. 膜
科学与技术，2011，31（3）：223~227.
[6] 熊瑞林，陈吕军，刘锐，等. MBR处理生活污水的效果研究[J]. 给水排水，2008,34（z2）：16~19.
[7] 谭德君，王雅琴，尤朝阳，等. 膜生物反应器处理生活污水的实验研究[J]. 水处理技术，2007，33（5）：37~40.
[8] 国家环境保护总局，水和废水监测分析方法编委会.水和废水监测分析方法[M].第四版.北京：中国环境科学出版社，2002.
[9] 曹春秋，司强，陈卫平，等. A2/O-MBR处理工业废水过程中膜污染及其清洗方案研究[J]. 给水排水，2010，36（10）：67~70.
[10] Ozaki Noriatsu，Yamamoto Kazuo．Hydraulic effects on sludge accumulation on membrane surface in crossflow filtration[J]．Wat Res 2001，35(13)：3137~3146．
[11] 王志伟，吴志超，顾国维，等.平板膜生物反应器操作运行条件对膜污染特性的影响[J]. 膜科学与技术，2005，25（5）：26~30.

Service：
【Download】【Collect】

《膜科学与技术》编辑部 Address: Bluestar building, 19 east beisanhuan road, chaoyang district, Beijing; 100029 Postal code; Telephone：010-80492417/010-80485372; Fax：010-80485372 ; Email：mkxyjs@163.com

京公网安备11011302000819号