采用自制的磺化聚丁二烯（LYF）做表面活性剂，以P204为萃取剂，以4mol/L HCl为内相，液体石蜡为膜稳定剂，制成乳状液膜，从模拟湿法磷酸中萃取了稀土镧。在膜内比为1.2 :1，制乳搅拌搅拌速度为2000 rpm，时间为20 min，提取搅拌速度为250 rpm，时间为10min，水乳比为2:1，磷酸浓度为10% P2O5，La3+含量为300 mg/L时，镧离子的迁移率达到86.67%。同时利用液液萃取通过斜率分析法讨论了P204从磷酸中提取镧离子的反应机理。对P204萃取镧离子进行了热力学研究，结果表明，萃取反应属于放热反应，反应热为-7.6971 kJ/mol。

Recently attention has been directed to wet-process phosphoric acid as a potential source of lanthanides. In this work emulsion liquid membrane which contained LYF (sulphonated polybutadiene) as surfactant, P204 as carrier, 2M HCl as internal phase, liquid paraffin as stabilizing agent was applied to removal of lanthanides. Results show that the degree of removal of lanthanides could be 86.67% with aqueous/organic phase ratio = 2:1, P2O5% = 15%, concentration of La3+ = 300 mg/L. The influence of various factors such as the concentration of H3PO4, H2PO42-, P204, HCl on the degree of removal has been established by liquid–liquid extraction. The mechanism of Lanthanide extraction from phosphoric acid by P204 has been determined via slope analysis. Meantime the results of thermomechanics show that the removal of lanthanide from phosphoric acid is an exothermic reaction with -7.6971 kJ/mol reaction heat. 

[1]  F. Bunu，R. Dumitrescu. Simultaneous extraction of rare earth elements and uranium from phosphoric acid [J]. Hydrometallurgy, 1992, 28: 331.
[2]  姚永发, 方天翰.　磷酸磷铵重钙技术与设计手册[M].北京:化学工业出版社, 1997.
[3]  施春华,胡瑞忠,王国芝.　贵州织金磷矿岩稀土元素地球化学特征研究[J].矿物岩石, 2004, 24(4): 71.
[4]  张杰,张覃,陈代良.贵州织金新华含稀土磷矿床稀土元素地球化学研究[J].地质与勘探, 2004, 40(1): 41.
[5]  张　杰,张　覃,陈代良.　贵州织金新华含稀土磷矿床稀土元素地球化学及生物成矿基本特征[J].矿物岩石, 2003,23(3): 35.
[6] Mohamed Krea, Hussein Khalaf. Liquid-liquid extraction of uranium and lanthanides from phosphoric acid using a synergistic DOPPA-TOPO mixture [J]. Hydrometallurgy. 2000（58）：215-225
[7] Bozena Kuznik, Anna Malinowska. Solvent extraction of rare metal ions with 1-(2-Pyridylazo)-2-Naphthol PAN) [J]. Monatshefte fur Chemie. 1987(118)：1325
[8] Xia Chuan-Bo, et al. Extraction of rare earth metal samarium by microemulsion [J]. Journal of Radio analytical and Nuclear Chemistry. 2008(275)：535.
[9]  R.Kopunec, J. C. Benitez. Extraction of rare earth elements with organophosphorus extractants as carriers in supported liquid membranes. Journal of Radio analytical and Nuclear Chemistry, 1991, 150: 269-280.
[10]  刘沛妍，褚莹，严忠. 水溶性聚合物和两亲聚合物19.磺化液体聚丁二烯——一种新型液膜用表面活性剂[J]. 功能高分子学报，1994, 7（4）：450-458.
[11]  刘海成, 李奉翠, 宋玉平. 硫酸钡光度法测定水中硫酸盐含量[J]. 平顶山工学院学报, 2004, 13(4)：46-47
[12]  铝及铝合金化学分析方法第24部分：稀土总含量
的测定GB/T 20975.24 —— 2008.
[13] 徐光宪, 袁承业. 稀土的溶剂萃取[M]. 北京：科学出版社, 1987
[14]  武汉大学化学系. 稀土元素分析化学(上) [ M ]. 北京：科学出版社，1981.
[15] 王良士,龙志奇等. 磷酸体系中微量稀土元素萃取回收技术研究[J]. 中国稀土学报, 2009, 27(2)：228-233
[16] Mohamed Saidi, Hussein Khalaf. Using microemulsion for recovery of uranium from phosphoric acid of Annaba (Algeria) [J]. Hydrometallurgy 74 (2004) 85-91